February 17, 2017 at 9:11am
The 627th Logistic Readiness Squadron Fuels flight provides fuel to the 48 C-17's at the 62nd Airlift Wing on Joint Base Lewis-McChord, but they do more than deliver the fuel to aircraft, they make missions possible.
The fuels flight provides support to not only our aircraft, our government vehicles, civilian aircraft that land here and deployment rotaters, they also provide support to the President of the United States.
"It's a cliché, but we always say without fuel, pilots are pedestrians," said Master Sgt. Keith Grady, 627th LRS fuel operations section chief. "Without fuel these planes can't get off the ground.
Grady oversees the fuel distribution element and fuel hydrants on base.
"Fuels distribution is in charge of issuing the fuel to the aircraft, transporting liquid oxygen carts as well as filling those carts with liquid nitrogen and liquid oxygen," said Grady.
As far as fuel capabilities go, they have two pump houses, which both can dispense 2,400 gallons each, per minute.
They also have 11 re-fuelers, which have 6,000 gallon tanks that can dispense up to 600 gallons of fuel per minute each.
"On an average day, we deliver between 75,000 to 200,000 gallons of fuel," Grady said. "That fuel is delivered to anywhere between six and twenty aircraft a day."
The process for re-fueling starts as a simple phone call from the 62nd Maintenance Group Maintenance Operations Center.
"One of our fuel service center controllers will log that request into our fuels manger defense program and at the same time they'll dispatch an operator to take a vehicle out," said Grady. "They will hand a vehicle clip board to that operator, the operator will check the paperwork, go out to the vehicle and do an inspection then drive out to the aircraft.
"They will get marshalled in, hook up the single point, ground and bond the aircraft and do all the preparation to fuel the aircraft."
Grady said during that time, there's a lot going on and the fuel distributor is always checking for safety hazards.
"They're pumping a lot of fuel and very fast," Grady said. "It can be very dangerous, so they are always checking their environment, but the whole process takes approximately an hour from the time the call comes in."
Before the fuel enters any aircraft, the fuel must be tested for safety and quality.
Staff. Sgt. Jason Drobish, 627 LRS fuels laboratory NCOIC, does just that.
"We are the first line of defense for any contamination within the fuel," said Drobish. "At the very first point where the fuel enters the base we sample and test the fuel for any additives and make sure those are within range."
The fuel comes from a barge that comes from a commercial contractor off base and then it is pumped through a pipe line on base.
"We are constantly testing our equipment throughout the month to make sure that the fuel meets specifications for water and additives," said Drobish. "We take a gallon sample, run them through some test membranes and we are able to see particular contamination such as sand or dirt or rust - things from the pipes."
It's beyond imperative that the fuel is tested and quality controlled.
"It's an important job," said Grady. "Just knowing the fuel that were putting on the aircraft is safe allows the plane to operate without any issues emanating from the fuel."
Providing the life blood to these aircraft, is the mission of the 627th LRS fuels flight and it is a mission they take very seriously.
22nd Special Tactics Squadron, 262nd Information Warfare Aggressor Squadron, 361st Recruiting Squadron, 446th Airlift Wing, 5th Air Support Operations Squadron, 62nd Airlift Wing, 62nd Maintenance Group, 62nd Medical Squadron, 62nd Mission Support Group, 62nd Operations Group, 728th Airlift Squadron, Afghanistan, Air Mobility Command, Air Rodeo, Awards, Ceremony, Contest, Defense News, Dependent, Deployment, Education, Environment, Family Readiness, Food and Drink, Furlough, Health, History, Holidays, Honors, Iraq, Joint Base Lewis-McChord, Lacey, Lakewood, Madigan, McChord Air Museum, McChord Base Exchange, McChord Commissary, Memorial, Military Discount, Military Policy, News To Us, Olympia, Space-A Travel, Sports, Tacoma, Training, U.S. Air Force, USO, Veterans, Web/Tech, Weekly Volcano, Western Air Defense Sector
Thanks for listing down some of the things to consider when buying renters insurance. I totally...
you are say about this Air Force highly recommends absolutely right and i appreciate your...
This is real take it serious, my name is marian i, who will believe that a herb can Cure...
Its always a treat to be able to get on base and all of the planes from around the world come...
Thanks for giving us nice info. Fantastic walk-through. I appreciate this post.
Read Comments